Specifications
| Fuel | LPG |
|---|---|
| Frequency | 60.0 Hz |
| Standby power | 6 kW |
| Prime power | 6 kW |
| Oil capacity | 1.4 L |
Maintenance & consumables
for the Generac GN-480| Item | Spec | Capacity | Part # | Interval | |
|---|---|---|---|---|---|
| Air filter | 073123 | 100 hr | Amazon eBay $28.00 | ||
| Fuel filter | 087769 | 100 hr | Amazon eBay $49.99 | ||
| Oil filter | 070185 | 100 hr | Amazon eBay $19.97 | ||
| Belt | Not explicitly stated in the document. | — | 500 hr | find | |
| Coolant | check level, add if necessary | — | 12 hr | ||
| Oil | High quality detergent oil classified 'For Service SF' and with an oil viscosity rating of SAE 10W-30 | — | 100 hr |
Common questions
What is the power rating of the Generac PRIMEPACT 66LP?
The Generac PRIMEPACT 66LP is rated 6 kW standby.
What engine does the Generac PRIMEPACT 66LP use?
The Generac PRIMEPACT 66LP is powered by the Generac GN-480 engine.
What fuel does the Generac PRIMEPACT 66LP use?
The Generac PRIMEPACT 66LP runs on LPG.
What is the oil capacity of the Generac PRIMEPACT 66LP?
The Generac GN-480 engine in the Generac PRIMEPACT 66LP has an oil capacity of 1.4 liters.
Troubleshooting
5Symptoms & remedies
| Symptom | Cause | Remedy |
|---|---|---|
| Engine won't crank. | 15 amp fuse blown. | Replace blown fuse. |
| Engine cranks, won't start. | Out of fuel. | Refill fuel tank. |
| Engine starts hard, runs rough. | Dirty engine air cleaner. | Clean or replace as needed. |
| Engine starts, then shuts down. | Engine oil level is low. | Add oil as needed. |
| No AC output voltage. | Main breaker(s) open. | Close main breaker(s). |
Fault codes and symptom→remedy steps extracted from this model’s service/owner documentation; verify against the official manual before servicing.
Parts
29| Part # | Description | Qty | System | |
|---|---|---|---|---|
| 030340 | HOSE, FUEL, 4.5" LG. | 1 | Hose | buy |
| 067805 | OIL SEAL | 1 | Seal | buy |
| 067816 | VALVE SPRING | 4 | Belt | buy |
| 067866 | O-RING | 1 | Seal | buy |
| 067897 | EXHAUST GASKET | 2 | Gasket | buy |
| 067920 | VALVE COVER GASKET | 2 | Gasket | buy |
| 067924 | OIL SEAL ASSEMBLY | 1 | Seal | buy |
| 069332 | CYLINDER HEAD GASKET | 2 | Gasket | buy |
| 069336 | OIL SUMP GASKET | 1 | Gasket | buy |
| 070070 | OIL PUMP ASSEMBLY | 1 | Pump | buy |
| 070122 | VALVE STEM SEAL | 4 | Seal | buy |
| 070185 | FILTER, OIL (FRAM#PH3614) | 1 | Oil filter | Amazon eBay $19.97 |
| 070547 | OIL PUMP ASSEMBLY | 1 | Pump | buy |
| 070596 | BREATHER TUBE | 1 | Hose | buy |
| 072347 | SPARK PLUG | 2 | Spark plug | Amazon eBay $2.50 |
| 073123 | AIR FILTER (NOT SHOWN) | 1 | Air filter | Amazon eBay $28.00 |
| 075258 | ENGINE GASKET KIT | 1 | Gasket | buy |
| 087769 | FUEL FILTER | 1 | Fuel filter | Amazon eBay $49.99 |
| 089870 | SOLENOID, FUEL SHUTOFF (Q-70G Only) | 1 | Sensor | buy |
| 0A8584 | FILTER, OIL (FRAM#PH3614) | 1 | Oil filter | FridayParts $31.60 |
| A8584 | 10 PSI-SWITCH, OIL PRESSURE | 1 | Sensor | buy |
| Champion.RC12YC | Spark Plug | Spark plug | buy | |
| 067890 | HEX NUT | 1 | Service part / kit | buy |
| 075252 | KIT, CARBURETOR OVERHAUL | 1 | Service part / kit | buy |
| 075271 | VALVE OVERHAUL KIT | 1 | Service part / kit | buy |
| 086313 | HOUSING, ENGINE TOP | 1 | Service part / kit | buy |
| 092120 | NUT LOCK TRIC M6-1.0 Y/ZNC | 2 | Service part / kit | buy |
| 099258 | KEY-WOODRUFF 6 x 22MM | 1 | Service part / kit | buy |
| 98773 | AIR-COOLED RECREATIONAL VEHICLE GENERATORS | 1 | Service part / kit | buy |
Service, wear & replacement parts referenced for this model and its engine — confirm the exact part for your serial number. See the full parts catalog to search and cross-reference.
Fuel consumption
| Rating | Load | L/h | gal/h |
|---|---|---|---|
| Prime | 0.33 | ||
| Prime | 0% | 0.42 | |
| Prime | 0% | 0.59 | |
| Prime | 1% | 0.69 | |
| Prime | 50% | 0.59 | |
| Prime | 100% | 0.99 |
Available documents
Installation manualOwner's manualParts manual